Factory-certified Specalists for BMW, Mini, Subaru, and FIAT

The “75k Mile List”

E34 5 Series (1995-2003, including M) Edition

After years of driving, racing and repairing BMWs, we have clearly identified the common problems and maintenance concerns that need to be addressed on nearly every middle-aged BMW. E34 5-series cars, like all BMWs, have specific areas that need to be inspected regularly, and buyers should require a pre-purchase inspection to verify the condition of these areas.

In this list, you will find items that should have been replaced or at least inspected by 75k-100k miles. Some are model specific and will be noted as such.

Areas of Concern:

Thrust Arm Bushing Failure

Symptoms: Shimmy under braking at freeway speed, vague or rubbery feel in steering, excessive front tire wear. Extreme examples produce a clunking sound. Torn or cracked thrust arm bushing is the most common suspension problem on the E34. Every 5 and 7 series car needs this part replaced by 75k miles, many by 40k miles.

Tie Rod Wear

Symptoms: Steering shimmy, clunking during steering input, inability to hold proper alignment. 5 and 7 series cars share the same basic front steering components, consisting of a tie rod end attached to each end of the center tie rod.

If any ball joint boot is cracked as indicated by grease coming out, it must be replaced. All components should also be checked for excessive play, and replaced if out of BMW spec.

Worn or Blown Shocks and Struts

Symptoms: Diving under braking and acceleration, excessive lean and suspension compression during cornering, bouncy and uncomfortable ride, shocks and struts visibly leaking shock oil. Factory BMW shocks on the 5 series are robust and commonly work well for over 100k miles. Because the deterioration is gradual, most BMW drivers hardly notice until the shocks and struts need replacement. EDGE recommends replacing factory units with quality shocks from Koni whenever possible. When replacing shocks and struts at 100k miles or more, the upper shock mounts, both front and rear may also need replacement.  It is also recommended to install lowering springs and adjust other areas of the suspension at the same time. You will be amazed at the difference a good set of shocks can make in both comfort and performance.

Worn or Failed Swaybar Endlinks

Symptoms: Metallic clicking noise and compromised handling. There is no critical danger in a failed swaybar endlink, but the handling of the car will be severely compromised. Ease of handling can be restored by simple replacement with new endlinks.

Torn Subframe and Subframe Bushings

Symptoms: Erratic handling, unidentified clunking and banging sounds from rear of the car. Especially prevalent on the E39 Touring, torn subframe bushings can lead to subframe failure.  Early detection of a torn or cracked subframe bushing can prevent costly subframe repair and welding.

E34 5 Series (1989-1995) | EDGE MotorworksE34 5 Series (1989-1995) | EDGE Motorworks image #2E34 5 Series (1989-1995) | EDGE Motorworks image #3

Torn or Cracked Transmission Mounts

Symptoms: Hard, notchy, forced shifting while cornering, excessive shifter jerk during hard acceleration and braking, muddy shifter feel. On manual transmission cars, torn transmission mounts can lead to the dreaded ‘money shift,’ or mechanical overrev and probable destruction of the car’s motor. Worn transmission mounts allow for an excess amount of transmission movement.

Ripped or Failed Guibo

Symptoms: Loud clunking sound before acceleration as the guibo bolts bind together. A torn guibo (Flex Disc) results in perceivable drivetrain elasticity.

E34 5 Series (1989-1995) | EDGE Motorworks image #4E34 5 Series (1989-1995) | EDGE Motorworks image #5

Dirty Automatic Transmission Fluid or Clogged Filter

Symptoms: Hesitation and/or hard shifting. If you are experiencing either of these, it could be the result of dirty and old automatic transmission fluid or a clogged transmission filter.

Water Pump Failure

Symptom: Rapidly overheating motor. Water pump failure is the easiest way to cause extensive and expensive damage to your BMW. When the bearing or impeller on the stock pump breaks, it disables the cooling system and can result in a warped head or even more severe engine damage. If your temperature gauge climbs above the ¾ mark TURN THE CAR OFF IMMEDIATELY AND CALL A TOW TRUCK.

To prevent water pump failure, we recommend changing out the water pump on six cylinder cars every 60-80k miles.

Cracked Radiator Necks

Symptom: Possible drastic drop in coolant level, possible overheating motor, but often no symptoms showing whatsoever. Unfortunately for BMW owners everywhere, the makers of this beautiful car love plastic radiators. These radiators become brittle and crack with age, particularly around the neck and often without warning. To prevent costly repairs or devastating damage, radiators should be replaced routinely every 80-100k miles. 

Thermostats and Housings

Symptoms: Car running hot or cold.

For 6 cylinder cars and E34 V8, the factory thermostat housing can eventually crack causing cooling system failure. Replacement with aluminum housing, or with the new composite units every 60k miles will prevent problems. We also recommend replacing the thermostat while the housing is off. Later E39s have electronically controlled MAP cooling thermostats. These will eventually fail as indicated by the check engine light. When this happens, the engine is running approximately 10 degrees hotter. This hurts mileage and will eventually hurt the engine.

If your temperature gauge climbs above the ¾ mark TURN THE CAR OFF IMMEDIATELY AND CALL A TOW TRUCK.

E34 5 Series (1989-1995) | EDGE Motorworks image #6

Fan Clutch Failure

Symptom: Fan clutch shows low resistance after driving (while the engine is still warm) when manually turning the fan clutch. Most fan clutches fail between 80 and 100k miles. They provide the primary cooling for your car and are easy for us to diagnose.

Accessory Belt and Tensioner Failure

Symptoms: Squealing noise from the engine bay and/or cracks in the belts, temperature gauge rising above the ¾ mark. If a belt snaps, the cooling system will fail as the water pump ceases to operate. Power steering and alternator will also fail. If you suspect belt failure or see the temperature gauge rise past the 3/4 mark TURN THE CAR OFF IMMEDIATELY AND CALL A TOW TRUCK.

E34 5 Series (1989-1995) | EDGE Motorworks image #7

Leaky Valve Cover Gasket

Symptom: Burning oil smell. Prevalent on all BMWs. If uncorrected, oil can seep into the spark plug holes and damage the ignition coils, resulting in costly replacement. Edge recommends replacing this inexpensive gasket when changing spark plugs as the coil packs will already be exposed.

O2 Sensor Failure

Symptoms: Poor mileage, poor idle and flat spots in the power curve. Even if your check engine light is on, your car may not be performing optimally. BMW recommends replacing the O2 sensors every 100k miles. Extended high-RPM running/racing and high-performance chips may shorten the replacement cycle.

Oil Separator

Symptoms: For 96+ 6 cylinder cars only, poor idle and periodic Check Engine lights showing. A deteriorated valve introduces a vacuum leak that will eventually cause the car to break down if neglected. Typical mileage is approximately 80k miles. Although the part is inexpensive, it requires approximately 4 hours of labor, depending on the year of the car. 

Clogged and Dirty Pollen Filter

Symptoms: Reduced flow of air from A/C or heater, and/or damp and musky smell. If either symptom is evident, it’s likely that the pollen microfilter of your car has become dirty and clogged over time. This is a service II replacement item.


4-Year Warranty
Make an Appointment

4 Year, 50,000 Mile Warranty

Good on all parts and service

  • BMW and MINI
  • Suspension and chassis
  • Engine and cooling systems
  • Transmission and driveline
  • Electronics
Warranty Details

Specials

1st Time Customer, 10% Off
As a new EDGE Motorworks Guest, you are eligible to receive 10% off labor work when you come in for a service.
FREE Check engine light code read!
Is your check engine light on? You could be damaging your engine by driving with the light on. Call for an appointment to have us read your check engine light code and determine what steps need to be ... [More] taken. Some restrictions may apply. not to be combined with any other offer. ... [Hide]
Complimentary Courtesy Inspection
Complimentary Courtesy Inspection with any service or repair.

Reviews

“For years I have looked for a BMW specialist that is knowledgeable, easy to work with, fair priced, and accommodating. Edge is my go to shop for both my street car and my track car.”
Winston C.
5

Maintenance

BMW, Porsche, MINI, Subaru, FIAT, Alfa Romeo, more

  • Fluids
  • Pre-purchase Inspections
  • Factory Warranties
  • Brake Service and Upgrades
  • Electrical Troubleshooting
  • Cooling System Service and Upgrade
  • Oil Service
view all services

Motorsports

BMW, Porsche, MINI, Subaru, FIAT,
Alfa Romeo, more

  • Race Builds
  • HPDE Inspections
  • Performance Modifications
  • Performance Assessment
  • Electrical Troubleshooting
  • Coaching
  • Trackside Services
  • Oil Service
view all services

Diagnose Your Car

This is about how a potential customer can check for symptoms on their own, at home.

  • BMW
  • Mini
  • Subaru
Check Your Car